In the years since this cabin fire we've learned a lot about how to make aircraft interiors less toxic in a fire, lavatory smoke detectors, and placarding. The crew could have benefitted from a good Emergency Vision Assurance System (EVAS) and better "Speed is Life" procedures.
— James Albright
Updated:
2012-09-26
Varig 820, from AirDisaster.com.
Remember, if you don't put the fire out in four minutes or less, you probably won't. If you don't get the airplane on the ground in fourteen minutes or less, you may not be able to on your own terms. More about the "Speed is Life" procedure: Cabin Fire/ Speed is Life.
1
Accident report
- Date: 11 July 1973
- Time: 14:03
- Type: Boeing 707-345C
- Operator: Varig
- Registration: PP-VJZ
- Fatalities: 7 of 17 crew, 116 of 117 passengers
- Aircraft Fate: Destroyed
- Phase: Approach
- Airports: (Departure) Rio de Janeiro-Galeao International Airport, RJ (GIG/SBGL), Brazil; (Destination) Paris-Orly (ORY/FLPO), France
2
Narrative
Varig Flight 820 departed Rio de Janeiro (GIG) at 03:03 for a flight to Paris-Orly (ORY). The en route part of the flight was uneventful. At 13:57 the aircraft had descended to FL080 and contacted Orly approach, who told the crew to maintain FL080 and head to the OLS VOR which would take the aircraft to the downwind leg of runway 26. At 13:58:20 the flight crew contacted Orly approach and reported a "problem with fire on board". An emergency descent was requested. At 13:59 clearance was given to descend to 3000 feet for a runway 07 landing, making a straight-in approach possible. While the situation on board was getting worse (smoke entering the cockpit and passengers becoming asphyxiated), a clearance to descend to 2000 feet was given at 14:01:10. The flight crew put on oxygen masks as smoke was making it impossible to read the instruments. At 14:03 the pilot decided to make an emergency landing 5 km short of the runway with gear down and flaps at 80deg. The Boeing approached with considerable nose-up attitude, in a slight left bank. The aircraft truncated some small trees and made a heavy landing on a field. Both main gears collapsed and the engines were torn off in the subsequent skid. The fuselage however, remained intact. Ten occupants (all crewmembers) evacuated the aircraft. By the time the firemen arrived (6-7 minutes later) the fire had burned through the roof and there was no sign of life. Of the four unconscious occupants the firemen could evacuate, only one survived.
4
Cause
"A fire which appears to have started in the washbasin unit of the aft right toilet. It was detected because smoke had entered the adjacent left toilet. The fire may have been started by an electrical fault or by the carelessness of a passenger. The difficulty in locating the fire made the actions of cabin personnel ineffective. The flight crew did not have the facilities to intervene usefully from the cockpit against the spread of the fire and the invasion of smoke. The lack of visibility in the cockpit prompted the crew to decided on a forced landing. At the time of touch-down the fire was confined to the area of the aft toilets. The occupants of the passenger cabin were poisoned, to varying degrees by carbon monoxide and other combustion products."